Repair Cable and Splices in Feeder from North Substation, Cape Canaveral Space Force Station, FL

Scope of Work The work to be performed under this project is located at Cape Canaveral Space Force Station (CCSFS). CCSFS is located at the end of State Road 401, north of Port Canaveral, Florida. The work to be performed under this project consists of providing the labor, equipment, and materials to replace 15kV Feeder 7N from CCSFS North Substation to Switch Station 37 (SS-37). Install ten (10) new Sectionalizing Terminal Cabinets along the feeder route to allow for troubleshooting. This will involve approximately 44 manholes and approximately 20,000 linear feet. Civil/Site. New concrete pads are designed to support the new electrical equipment and trenching and pavement repair will provide electrical and control service routing. Excavations are not anticipated to encounter groundwater. The scope of work will not create enough new impervious to require Environmental Resource Permitting (ERP) with St. Johns River Water Management District (SJRWMD). A permit determination letter will be prepared, identifying the new impervious area, less than 300 square feet. No existing solid waste management units (SWMU) are anticipated to be directly impacted as part of this project. Architectural. Demolish stand-alone electrical vaults, buildings 905, and 972. Core drill through walls, as shown in the drawings, to facilitate the installation of new electrical feeders. Provide new concrete pads for new electrical equipment per the drawings. Electrical. Replace existing Feeder 7N with new 3-1/C, 350 kcmil, 15 kV, cooper conductor with 1/3 concentric neutral and 133%, type Ethylene-Propylene Rubber (EPR) insulation. Install new feeder from CCSFS North Substation to Switch Station 37 (SS-37) including feeders supplying LBS-7N1, LBS-CPF3, LBS-3N4, LBS-3N6, LBS-7N2 and LBS-7N3. Install nine (9) new 3P, 15 kV, 600 Amps 3-way Sectionalizing Terminal Cabinets (STC) along feeder 7N and one (1) STC for feeder 10N at Manhole NE-15 to allow for troubleshooting. Field measure and procure 15 kV cable to allow installation without any splices.

Electric Substation, Demolition.

Division 03 -	Concrete, Concrete Forming, Cast-in-Place Concrete.
Division 04 -	Masonry, Unit Masonry.
Division 05 -	Metals, Structural Metal Framing.
Division 26 -	Electrical, Instrumentation and Control for Electrical Systems, Substations, Power Distribution Units, Transfer Switches.
Division 31 -	Earthwork, Clearing and Grubbing, Grading.
Division 32 -	Exterior Improvements, Fences and Gates.