Rockwood Fire Station Expansion

Somerset County (for the Rockwood Fire Department, Rockwood, ME) is requesting proposals for the expansion/ addition (18’ x 60’) of the Rockwood Fire Station in Rockwood Maine. This project is to be done this year with a start this spring/ early summer. 1. Scope of Work to be performed by Contractor A. Remove trees to the left (South) side of the station in the building area B. Prepare the ground for the slab. Run a compaction test on the fill material. C. Put down 2 inches of insulation under the slab; install a 6” (inch) slab pinned to the existing with a raised haunch to match the existing building. A floor drain is not required. D. Run radiant heat lines in the slab and tie into the existing system E. Pour floor with 4000PSI mix and re-bar. Use #4 or #5 rebar, 12” on center each way. Concrete must pass an ASTM test for strength. F. Frame walls with 2 x 6 construction, 16” apart G. Remove shingles on the South (left) side of roof and redo with addition to match north (right) side H. Sheath the entire addition roof for ice and water, then shingle I. Install metal siding to match existing siding J. Install new powered overhead 14’ x 14’ door to match existing doors K. Cut a new entrance doorway in the new addition. Take out a window and cut cement to the floor. Remove rear door for a second access point L. Install new full metal rear entrance door in back of the new addition M. Install all new electrical lines to include outlets, LED ceiling lights and tie into the existing electrical panel. N. Install a new water line and hose bibb in the new addition. O. Install two (2) 10 lb. ABC Fire Extinguishers in the new addition. P. Install in the ceiling a high quality retractable 30’ air hose and a 30’ 12/ 3 retractable conductor cord. No specific brand required

Fire/Police Station, 1,080 SF Addition.

Division 03 -	Concrete, Concrete Forming, Cast-in-Place Concrete.
Division 04 -	Masonry, Unit Masonry.
Division 05 -	Metals, Structural Metal Framing.
Division 06 -	Wood, Plastics, and Composites, Rough Carpentry, Finish Carpentry.
Division 07 -	Thermal and Moisture Protection, Dampproofing and Waterproofing, Thermal Protection, Weather Barriers.
Division 08 -	Openings, Metal Doors and Frames, Wood Doors, Plastic Doors, Specialty Doors and Frames, Panel Doors, Multi-Leaf Vertical Lift Doors.
Division 09 -	Finishes, Plaster and Gypsum Board, Tiling, Flooring, Acoustic Treatment, Painting, High-Performance Coatings.
Division 10 -	Specialties, Signage, Compartments and Cubicles, Toilet Compartments, Shower and Dressing Compartments, Toilet, Bath, and Laundry Accessories, Emergency Aid Specialties, Fire Protection Specialties, Lockers, Wardrobe and Closet Specialties, Flagpoles, Flags and Banners.
Division 11 -	Equipment, Unit Kitchens.
Division 12 -	Furnishings, Countertops, Rugs and Mats.
Division 14 -	Conveying Equipment, Slide Pole Systems, Firehouse Slide Poles.
Division 21 -	Fire Suppression, Facility Fire-Suppression Water-Service Piping, Fire-Department Connections, Fire Pumps.
Division 22 -	Plumbing, Instrumentation and Control for Plumbing, Facility Water Distribution, Facility Storm Drainage, Plumbing Equipment, Plumbing Fixtures, Emergency Plumbing Fixtures, Drinking Fountains and Water Coolers.
Division 23 -	Heating, Ventilating, and Air Conditioning (HVAC), Instrumentation and Control for HVAC, HVAC Piping and Pumps, HVAC Air Distribution.
Division 26 -	Electrical, Power Distribution Units, Interior Lighting, Emergency Lighting, Exit Signs, Exterior Lighting.
Division 27 -	Communications, Structured Cabling, Call Management, Distributed Audio-Video Communications Systems.
Division 28 -	Electronic Safety and Security, Electronic Detection and Alarm, Fire Detection and Alarm.
Division 31 -	Earthwork, Clearing and Grubbing, Grading, Soil Treatment.
Division 32 -	Exterior Improvements, Bases, Ballasts, and Paving, Flexible Paving, Asphalt Paving, Rigid Paving, Concrete Paving, Curbs, Gutters, Sidewalks, and Driveways.
Division 33 -	Utilities, Water Utilities, Sanitary Sewerage Utilities, Storm Drainage Utilities.