Albion Road Cap Beam Replacement

The Albion Rd Bridge over Oak Orchard Creek is a timber deck bridge with sheet pile abutments and wingwalls. The bridge was replaced in 1983, and though the timber girders and deck are holding up well, the steel cap beam is deteriorating at the bridge begin and bridge end. This bid shall be for the removal, furnishing and installation of W beam cap beam and stiffeners on bridge begin and bridge end and beam seats including bearing plates, rubber pad, angle connections, and bolts. The Contractor will be responsible for the following work items: 1. Provide WZTC for duration of project. Road can be closed to all traffic during construction. No detour is necessary, only “Bridge closed ahead” signs at nearest intersection to the north and south, 1000 ft and 500 ft warning signs, “road closed” signs and Type III barricades. 2. Unbolt and set aside bridge rail during construction, and reinstall once work is complete. 3. Provide steel cap beam and connection design, stamped by a NYS Licensed Professional Engineer. Design will be reviewed by County engineering staff prior to ordering any materials. 4. Remove and dispose of existing cap beam, bearing plates, bearing pads, girder connections and bolts on both ends of bridge. 5. Furnish and install new hot dipped galvanized cap beam, new bearing plates, new stiffeners, new girder connections, and new bolts at both ends of bridge. 6. Any damage to roadway, bridge deck, bridge appurtenances, or sheet pile once contractor is mobilized is the responsibility of the contractor.

Bridge, Renovation.

Division 01 -	General Requirements, Vehicular Access and Parking, Traffic Control, Temporary Barriers and Enclosures.
Division 03 -	Concrete, Concrete Reinforcing, Precast Structural Concrete.
Division 05 -	Metals, Structural Steel Framing, Structural Steel for Bridges, Steel Joist Framing, Steel Joist Girder Framing.
Division 07 -	Thermal and Moisture Protection, Expansion Control.
Division 09 -	Finishes, High-Performance Coatings.
Division 10 -	Specialties, Signage, Traffic Signage.
Division 26 -	Electrical, Exterior Lighting, Lighting Poles and Standards, Roadway Lighting.
Division 31 -	Earthwork, Embankments, Erosion and Sedimentation Controls, Slope Protection, Gabions, Riprap, Special Foundations and Load-Bearing Elements, Driven Piles.
Division 32 -	Exterior Improvements, Bases, Ballasts, and Paving, Flexible Paving, Rigid Paving, Fences and Gates, Retaining Walls.
Division 34 -	Transportation, Bridges.