Tarta Transit Storage & Maintenance Facility Roof Replacement

**As of September 27, 2023, project was awarded but awarded amount is not available.** All inquiries shall be in an email form to the email addresses listed below. Those inquiries and answers will be distributed to Proposers via addenda. The deadline to submit questions is August 1, 2023, at 2:00 pm EST. Additional IFB Information and Questions: Email: Jojones@tarta.com John Jones, Director of Maintenance and aschiavone@tarta.com Antonio Schiavone III, Facilities, Building, and Grounds Manger Scope of Services: Located at Toledo Area Regional Transportation Authority (TARTA) Central Ave. Campus, scope of work includes Main Building and Wash Bay Building Roof Replacement. General Project Description: The project consists of a full roof replacement of the entire facility, both garage and office portions, as well as the wash bay building toward the rear of the property. A full tear off of the existing roof down to the deck, removal of existing flashings and copings, and installation of all new insulation, roofing, flashings, waterproofing, copings, curbs, etc. is expected. Replacement BASE BID: SBS Modified Bituminous Membrane Roofing The scope includes the removal of the existing Roof Sections on Main Building and Wash Bay Building roof system and components down to existing decking, inspect for deficiencies, install R25 (minimum) of polyisocyanurate insulation in two layers, staggering joints, mechanically attached (adhered completely over new vapor barrier for concrete decking), adhere 1/2 " SecuRock recovery board per wind up-lift calculations, sump all drains using tapered insulation to an (8') diameter to promote positive drainage, install (hot-applied) fiberglass reinforced modified base sheet and SBS modified cap sheet throughout the field of the roof per plans and specifications. Install in a shingle fashion from low to high point of the roof slope to promote positive drainage. Install fiberglass/polyester modified base sheet (cold-applied) and modified mineral cap sheet to all flashings, heat-weld all flashing seams and roll to ensure proper adhesion, hot apply flood coat at specified rate and embed double-washed pea-gravel throughout field. Install new 22-gauge steel metal raised metal edge to match existing color. Apply two coats of aluminized coating to all exposed mineral-surfaced flashings and roof-top penetrations. Clean up all debris and damage done to grounds, building and roof top (if any). Charcoal filters to be utilized at intakes the duration of the project. Provide 2-year workmanship warranty. Manufacturer warranty to be provided upon completion. The specific objective for this project is to provide main building and wash bay building roof replacement at Toledo Area Regional Transportation Authority (TARTA) Central Ave. campus. TARTA reserves the right to reject any or all bids and waive any minor informalities or irregularities. Proposal Submission The proposer shall submit these additional documents following the bid and before the contract award: a) One (1) original hard (paper) copy with signed forms. b) Two (2) hard (paper) copies - copies are not required to have vendor required forms attached. c) One copy (electronic submission - including forms) to sgiviyan@tarta.com, zmorrison@tarta.com, pbringolf@tarta.com, aschiavone@tarta.com and jojones@tarta.com OR via USB flash drive All bids are sealed and marked with the IFB number and description of the IFB. TARTA is not responsible for late bids. Bids received after the stated time will not be accepted.

Division 07 -

Thermal and Moisture Protection, Dampproofing and Waterproofing, Thermal Protection.